Abstract
Recently, the recovery of nutrients from nutrient-rich wastewater has attracted considerable attention as a sustainable alternative to contaminant removal. This study investigated the recovery of nitrogen (N) and phosphorus (P) from the effluent of an anaerobic digester treating swine wastewater in Hue City, Vietnam, through struvite precipitation. The effects of pH, reaction time, and NH4+/Mg2+/PO43– (AMP) molar ratio on nutrient recovery efficiency and struvite formation were evaluated by using a Jar-Test system. The results reveal that increasing pH adversely affected N recovery because of NH3 volatilisation, whereas P recovery and struvite formation improved slightly. The best struvite formation was observed at pH 9.0, the reaction time of 30 min, and the AMP molar ratio of 1:1.5:1.5 with a recovery efficiency above 90% and the N and P removal efficiencies of 70% and 57.1%, respectively. X-ray diffraction analysis confirmed that struvite was the primary crystalline product. Additionally, the struvite precipitate contained 4.6% N, 12.5% P, and 11.4% Mg under the most appropriate conditions. This study demonstrates that struvite precipitation efficiently recovered nutrients from anaerobic digestion effluents.
References
- Wu X, Nawaz S, Li Y, Zhang H. Environmental health hazards of untreated livestock wastewater: Potential risks and future perspectives. Environmental Science and Pollution Research. 2024;31(17):24745-67.
- Fridrich B, Krčmar D, Dalmacija B, Molnar J, Pešić V, Kragulj M, et al. Impact of wastewater from pig farm lagoons on the quality of local groundwater. Agricultural Water Management. 2014;135:40-53.
- Burkholder JM, Mallin MA, Glasgow Jr HB, Larsen LM, McIver MR, Shank GC, et al. Impacts to a coastal river and estuary from rupture of a large swine waste holding lagoon. Journal of Environmental Quality. 1997;26(6):1451-66.
- Nasir IM, Mohd Ghazi TI, Omar R. Anaerobic digestion technology in livestock manure treatment for biogas production: a review. Engineering in Life Sciences. 2012;12(3):258-69.
- Deng L-W, Zheng P, Chen Z-A. Anaerobic digestion and post-treatment of swine wastewater using IC–SBR process with bypass of raw wastewater. Process biochemistry. 2006;41(4):965-9.
- Rajagopal R, Rousseau P, Bernet N, Béline F. Combined anaerobic and activated sludge anoxic/oxic treatment for piggery wastewater. Bioresource Technology. 2011;102(3):2185-92.
- Saliu T, Oladoja N. Nutrient recovery from wastewater and reuse in agriculture: a review. Environmental Chemistry Letters. 2021;19(3):2299-316.
- Bernet N, Béline F. Challenges and innovations on biological treatment of livestock effluents. Bioresource technology. 2009;100(22):5431-6.
- Li S, Qu W, Chang H, Li J, Ho S-H. Microalgae-driven swine wastewater biotreatment: Nutrient recovery, key microbial community and current challenges. Journal of Hazardous Materials. 2022;440:129785.
- Samanta P, Schönettin HM, Horn H, Saravia F. MF–NF treatment train for pig manure: nutrient recovery and reuse of product water. Membranes. 2022;12(2):165.
- Ledda C, Schievano A, Salati S, Adani F. Nitrogen and water recovery from animal slurries by a new integrated ultrafiltration, reverse osmosis and cold stripping process: A case study. Water Research. 2013;47(16):6157-66.
- Limoli A, Langone M, Andreottola G. Ammonia removal from raw manure digestate by means of a turbulent mixing stripping process. Journal of Environmental Management. 2016;176:1-10.
- Zhou S, Wu Y. Improving the prediction of ammonium nitrogen removal through struvite precipitation. Environmental Science and Pollution Research. 2012;19:347-60.
- Hao X-D, Wang C-C, Lan L, Van Loosdrecht M. Struvite formation, analytical methods and effects of pH and Ca2+. Water Science and technology. 2008;58(8):1687-92.
- Lourinho G, Rodrigues L, Brito P. Recent advances on anaerobic digestion of swine wastewater. International Journal of Environmental Science and Technology. 2020;17(12):4917-38.
- Ryu H-D, Lim DY, Kim S-J, Baek U-I, Chung EG, Kim K, et al. Struvite precipitation for sustainable recovery of nitrogen and phosphorus from anaerobic digestion effluents of swine manure. Sustainability. 2020;12(20):8574.
- Kim D, Min KJ, Lee K, Yu MS, Park KY. Effects of pH, molar ratios and pre-treatment on phosphorus recovery through struvite crystallization from effluent of anaerobically digested swine wastewater. Environmental Engineering Research. 2017;22(1):12-8.
- Uludag-Demirer S, Demirer GN, Chen S. Ammonia removal from anaerobically digested dairy manure by struvite precipitation. Process biochemistry. 2005;40(12):3667-74.
- Kwon G, Kang J, Nam J-H, Kim Y-O, Jahng D. Recovery of ammonia through struvite production using anaerobic digestate of piggery wastewater and leachate of sewage sludge ash. Environmental technology. 2018;39(7):831-42.
- Astals S, Martínez-Martorell M, Huete-Hernández S, Aguilar-Pozo V, Dosta J, Chimenos J. Nitrogen recovery from pig slurry by struvite precipitation using a low-cost magnesium oxide. Science of The Total Environment. 2021;768:144284.
- Ye Z-L, Chen S-H, Lu M, Shi J-W, Lin L-F, Wang S-M. Recovering phosphorus as struvite from the digested swine wastewater with bittern as a magnesium source. Water Science and Technology. 2011;64(2):334-40.
- Wang H, Wang X, Chen J, Xia P, Zhao J. Recovery of nutrients from wastewater by a MgCl 2 modified zeolite and their reuse as an amendment for Cu and Pb immobilization in soil. RSC Advances. 2016;6(61):55809-18.
- Lee EY, Oh MH, Yang S-H, Yoon TH. Struvite crystallization of anaerobic digestive fluid of swine manure containing highly concentrated nitrogen. Asian-Australasian journal of animal sciences. 2015;28(7):1053.
- Vidlarova P, Heviankova S, Kyncl M, editors. Contribution to the study of ammonia removal from digestate by struvite precipitation. IOP Conference Series: Earth and Environmental Science; 2017: IOP Publishing.
- Rice EW, Bridgewater L, Association APH. Standard methods for the examination of water and wastewater: American public health association Washington, DC; 2012.
- Kanda J. Determination of ammonium in seawater based on the indophenol reaction with o-phenylphenol (OPP). Water Research. 1995;29(12):2746-50.
- Wang J, Song Y, Yuan P, Peng J, Fan M. Modeling the crystallization of magnesium ammonium phosphate for phosphorus recovery. Chemosphere. 2006;65(7):1182-7.
- González-Morales C, Fernández B, Molina FJ, Naranjo-Fernández D, Matamoros-Veloza A, Camargo-Valero MA. Influence of pH and temperature on struvite purity and recovery from anaerobic digestate. Sustainability. 2021;13(19):10730.
- Ha T-H, Mahasti NN, Lu M-C, Huang Y-H. Ammonium-nitrogen recovery as struvite from swine wastewater using various magnesium sources. Separation and Purification Technology. 2023;308:122870.
- Çelen I, Türker M. Recovery of ammonia as struvite from anaerobic digester effluents. Environmental technology. 2001;22(11):1263-72.
- Taddeo R, Honkanen M, Kolppo K, Lepistö R. Nutrient management via struvite precipitation and recovery from various agroindustrial wastewaters: Process feasibility and struvite quality. Journal of environmental management. 2018;212:433-9.
- Lu X, Shih K, Li X-y, Liu G, Zeng EY, Wang F. Accuracy and application of quantitative X-ray diffraction on the precipitation of struvite product. Water research. 2016;90:9-14.
- Huang H, Yang J, Li D. Recovery and removal of ammonia–nitrogen and phosphate from swine wastewater by internal recycling of struvite chlorination product. Bioresource Technology. 2014;172:253-9.
- Westerman PW, Bowers KE, Zering KD. Phosphorus recovery from covered digester effluent with a continuous-flow struvite crystallizer. Applied Engineering in Agriculture. 2010;26(1):153-61.
- Aghdam S. Environmental Impact Assessment (LCA) and Techno-Economic Assessment (TEA) of struvite recovery in swine manure: North Carolina State University; 2022.

This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.
Copyright (c) 2025 Array